Alert: Notifications and correspondence during COVID-19 restrictions
We are operating at reduced capacity due to the COVID 19 alert level four requirements. Find out more about how to correspond and notify us during this time.
Carbon monoxide poisoning, overheating or mishandled fuel canisters and faulty equipment are all problems you can encounter with your gas camping equipment. Follow the steps on this page to stay safe while camping.
Carbon monoxide poisoning
Camping appliances need air. In New Zealand, the majority of deaths associated with the use of camping appliances have been attributed to carbon monoxide (CO) poisoning.
- Without proper ventilation, stoves and lamps can give off poisonous carbon monoxide.
- A faulty appliance may also emit carbon monoxide even in well ventilated areas.
- Carbon monoxide is highly toxic.
While carbon monoxide is odourless, it is accompanied by other emissions that may produce a ‘car exhaust’ smell.
Carbon monoxide poisoning can produce the following symptoms:
- dizziness and/or
- a desire to sleep
- prolonged exposure or high levels of carbon monoxide will result in collapse, unconsciousness and even death.
When hydrocarbon fuels (gas, white spirits, or solid fuels) burn they combine with oxygen to produce heat and light through a series of chemical reactions. In normal circumstances, carbon dioxide and water vapour are produced during this combustion process.
However, it these reactions are interfered with in some way, then carbon monoxide may also be emitted.
If there is inadequate oxygen to sustain complete combustion due to a lack of ventilation, carbon monoxide is generated.
If a pot is placed directly on the burner head rather than being offset by the metal stand (trivet), the flame is cooled and the combustion process is restricted, resulting in the production of lethal carbon monoxide.
Using a billy that is too big for the stove may also cool the flame, resulting in the production of carbon monoxide due to incomplete combustion.
If an appliance is faulty it may produce carbon monoxide even if used with good ventilation. In such cases it becomes extremely dangerous to use the appliance in a small enclosure such as a tent, car or a poorly ventilated caravan. The poisonous gas can build up to fatal levels as it cannot be diluted by incoming fresh air quickly enough.
- Use appliances outside whenever possible.
- Never use in confined spaces such as small tents.
- If inside, make sure there’s plenty of space and ventilation.
- Ventilation should allow air to move across the space with openings at high and low levels.
- Keep appliances in good condition.
- Always follow the manufacturer’s instructions.
- Give your flame room to burn – it should just touch the bottom of the pot.
- Do not use appliances if they are giving off a smell as this indicates leaking gas or emissions linked to carbon monoxide poisoning.
- If your appliance is malfunctioning – stop using it.
If a person is suffering from carbon monoxide poisoning
- Move them outside immediately to fresh air.
- Call for medical assistance and monitor them constantly until help arrives.
- Be prepared to start CPR if necessary.
- Extreme care must be taken when evacuating a person suffering carbon monoxide poisoning to ensure the rescuer does not become another victim. Be aware that the victim may not recognise their own symptoms due to impaired judgement.
LPG canister overheating
LPG canisters contain butane, propane or a mixture of the two in liquid form. If a cooking utensil with a highly reflective surface such as a hand-held toaster is used on a LPG cooker with a fuel tank attached, then the heat radiating down can overheat the canister to the point where the canister will rupture.
When heated, the liquid gas inside the canister will start to boil which leads to an increase in pressure inside the canister. Exposure to excessive temperatures will lead to dangerous pressures that may rupture the canister. If there is any source of ignition, the escaping gas will ignite creating a large explosion.
Problems may also occur with table top cookers where the canister is inside the case of the appliance. These cookers can be misused by operating with the trivet upside down. This results in overheating of the canister and rupture as above. Using a cooking vessel that is too large or placing two cookers close together may also result in canister overheating and rupture.
Storage and disposal of fuel canisters
When you have finished using an appliance, turn it off securely or it will continue to produce unburnt gas. Always store fuel canisters in a cool place out of direct sunlight. Canisters placed on the back window shelf of cars have ruptured!
- Always change canisters on appliances outside once they have cooled down, especially when other appliances are being used inside as the canister may still contain some fuel that could be ignited.
- Other liquid fuelled appliances should also be refuelled outside (once they have cooled down) for the same reasons.
- If using a gas burner that doesn’t have a resealable cylinder, you must make sure it is completely empty before detaching it. Otherwise unused gas will escape and may explode if the gas is ignited.
- Never dispose of empty canisters by throwing them in the fire. They may not be completely empty and will explode.
- Respect the outdoors, pack out what you pack in.
Inadequately maintained and faulty appliances
Appliances wear out. Plastic and rubber seals will deteriorate resulting in fuel leakage. The jets in burners can become clogged, resulting in incomplete combustion.
If parts of the appliance go missing, it may not function correctly and it may be dangerous to use. For instance a missing trivet may lead to a cooking pot being placed too close to the flame. This will cause incomplete combustion, resulting in the production of poisonous carbon monoxide.
- Make sure your appliances are in good working order before you leave home.
- If you suspect there is a problem take it to an appropriate servicing agency or dispose of it safely.
- Do not use synthetic gloves/clothing to handle hot appliances or to refuel an appliance.
- Synthetic material can melt and stick to the skin when heated.